Journal Article
Seasonal dynamic modeling and simulation of solar thermal membrane desalination system for sustainable freshwater production: a case study of Tanta, Egypt
S. A. El-Agouz; Ayman Refat Abd Elbar; Mohamed E. Zayed; Ali M. Aboghazala; Mohamed Z. Khatab; M. Y. Zakaria; Khaled Khodary Esmaeil
Environment, Development and Sustainability · Vol. 27, Issue 5 · pp. 10083-10108 · 2023
Abstract
Membrane distillation (MD) is an effective process for desalinating seawater, combining the merits of both thermal and membrane distillation. In this context, the sizing methodologies and optimization strategies are developed from the balance of the system’s energy demand. Therefore, accurate numerical modeling of the heat transfer and thermodynamic behavior of the MD systems is crucial for the optimal design of solar-based MD systems. The interest in utilizing solar thermal heating techniques for feed water heating in MD systems is increasing worldwide for sustainable freshwater production and lowering energy consumption. Hence, in this research, a coupled analytical modeling based on heat transfer, mass transport, and thermodynamic analysis is created to dynamically simulate a solar direct contact membrane distillation system (SDCMDS) driven by vacuumed tubes solar collectors (VTSCs) to analyze its performance, under real weather of Tanta, Egypt. The influences of the solar collecting area on the performances of the proposed SDCMDS for augmenting the freshwater production of the SDCMDS are studied. Four cases of the proposed SDCMDS are investigated: two identical VTSCs of 1.80 m 2 each unit in summer (Case I), two identical VTSCs in winter (Case II), four identical VTSCs in summer (Case III), and four identical VTSCs in winter (Case IV). The results show that the utilization of four VTSCs connected in series significantly improved the feed seawater temperature range from 30.0 to 70.5 °C compared to a feed temperature range of 30.0–49.5 was achievable by utilizing only two VTSCs. Moreover, the daily averaged permeate flux were 2.21, 1.29, 3.41, and 2.07 L/day per m 2 of solar harvesting area with daily cumulative distilled water yield of 7.48, 4.60, 23.04, and 14.78 L/day for Cases I, II, III, and IV, respectively, at a saline flowrate of 0.20 kg/s. The daily average total efficiency of the SDCMDS was obtained to be 14.70%, 12.50%, 24.95%, and 22.50% for Cases I, II, III, and IV, respectively.